Sliding Door Glass Shattered

Because sliding glass door panes are tempered they re inherently prone to spontaneous shattering.

Sliding door glass shattered.

I was glad that the curtain was closed because it just burst. More rarely doors can break due to nickel sulfide inclusion a defect that occurs during the manufacturing process. Most often shattering will occur as a result of fluctuations in temperature. If the expansion is large enough and the particle is located in the center tension zone of the tempered glass panel the resulting stress may be enough to shatter the glass.

A rock launched by a lawnmower just shattered the glass on our andersen brand sliding patio door. Slide a putty knife in between the trim and the door and then use a small pry bar and hammer to ease it off. When tempered glass is broken as shown above it shatters into thousands of tiny pebbles practically eliminating the danger of human injury caused by sharp edges and flying shards of glass. If a windstorm blew a tree limb through your sliding glass door the replacement would be covered under most policies but if the door was damaged because your child slammed it for example then the repairs or replacement would be an out of pocket expense.

It can be done with the door in place. For example if it s cold outside and a heat vent is located very close to the glass door pane itself the sudden heating of the glass could cause the pane to. After doors were installed the handle sounded like it was brittle as if the glass surrounding the handle was cracked. Baltimore on a cold day in february evelyn businsky was on her couch when the sliding glass door behind her spontaneously shattered.

And while it s not common by any means it does happen and can take homeowners by surprise when it does. The moving side was replaced even though the sound seemed the same. I agree that doors delivered to large retailers have more risk of damage that is not visible. The first thing you need to do is remove the trim around the glass which is known as the mull.

I think we have the details for the contractor that installed the doors 15 years ago and will give them a call to discuss repairs. When a piece of foreign material gets trapped inside the glass when it is manufactured over time it can cause the glass to shatter for no obvious reason. Replacing the glass on sliding patio doors doesn t mean removing the entire door. Why would a sliding glass door spontaneously shatter.

Broken glass on sliding patio door. Years later the stationary door interior glass shattered one night. Additionally defects in your exterior doors are a safety concern as damage can make it easier for intruders to break in and. Bella sliding glass door installation was the clue to why the stationary door interior glass exploded.